KODIAK 100 NOTIFICATIONS KODIAK 900 NOTIFICATIONS
Service Bulletins Service Notices Service Information Flight Infomation Letter

Service Bulletins Service Information Service Notices

Document Title Effective Date Revision Compliance Effectivity Status
SB24-01 Pitch Trim Actuator Maintenance 04/02/2024 01 Mandatory Original Effective Date: 04/02/2024 Serial Range: 100-0001 through 100-0338 Active
SB23-02 Rudder Cable Pass Through Crack and Buckle Inspection 08/02/2023 00 Mandatory Original Effective Date: 08/02/2023 Serial Range: 100-0001 through 100-0320 Active
SB23-01 TKS Anti-Ice System Pump Installation Modification 02/10/2023 00 Recommended Original Effective Date: 03/01/2023 Airplane Serial Range: 100-0001 and subsequent that are: a. equipped with External Cargo Compartment (ECC) Tank Part Number (PN): 100‑830‑1860 b. ECC Tank Serial Numbers: 0001 thru 0499 Active
SB21-01 PITCH TRIM ACTUATOR FASTNER REPLACEMENT 05/26/2021 00 Mandatory Serial Range: 100-0001 through 100-0287 Active
SB20-01 MCU POLARITY PROTECTION UPGRADE 07/29/2020 00 Recommended Serial Range: 100-0001 and subsequent that are equipped with an MCU (JB405-2) at Revision D or prior. Airplanes 100-0001 through 100-0282 were originally equipped with MCUs that would be impacted by this bulletin. Active
SB19-05 CREW SEAT AFT WHEELS UPGRADE AND RESOLUTION 11/29/2019 00 Mandatory Airplane serial range: 100-0001 through 100-0278 Active
SB19-04 OBSTACLE LANDING DISTANCE ERRORS 07/08/2019 00 Mandatory Airplane serial range 100-0001 thru 100-0274 Active
SB19-03 INSPECTION OF RUDDER TORQUE TUBE BONDING 11/05/2019 01 Mandatory Rudder Serial Range: 001 through 284 Active
(*** SB Number 19-02 Not Used ***)
SB19-01 REDUCED FUEL-TRANSDUCER ORIFICE 09/30/2019 00 Mandatory Airplane serial range: 100-0001 through 100-0274 Active
SB18-03 THROTTLE-CONTROL BRACKET THREAD ENGAGEMENT 01/29/2019 00 Mandatory Airplane serial range 100-0001 thru 100-0258 Active
SB18-02 JAPANESE REGISTERED AIRPLANE PLACARDS 01/29/2019 00 Mandatory Airplane serial range 100-0001 thru 100-0204, for aircraft that were Japanese registered prior to the effective date of this Mandatory SB. Active
SB18-01 NOSE LANDING GEAR (NLG) FORK INSPECTION 06/12/2018 02 Mandatory Airplane serial range 100-0001 and subsequent, which are: a. equipped with NLG Fork P/N 100-410-7001 and; b. certificated in any category Active
SB16-04 FIREWALL BLANKET RETROFIT 07/07/2016 01 Mandatory KODIAK® 100 Series Airplane Serial Numbers 100-0001 thru 100-0161 Active
SB16-03 FLOOR FRAME, CRACK REPAIR FSI179 07/31/2017 02 Mandatory KODIAK® 100 Series Airplane Serial Numbers 100-0001 thru 100-0152 Active
SB16-02 FLAP GEARBOX CONTROLLER AND AILERON TRIM ACTUATOR REPLACEMENT 02/17/2016 00 Recommended KODIAK® 100 Series Airplane Serial Numbers 100-0086 thru 100-0110 or airplanes subsequently equipped with the ... Active
SB16-01 INSPECT VISOR BRACKET MOUNT JOINT 01/12/2016 00 Mandatory KODIAK® 100 Series Airplane Serial Numbers 100‐0001 thru 100‐0159 Active
SB15-05 MAIN LANDING GEAR TIRE TUBES 12/28/2015 01 Mandatory KODIAK® 100 Series Airplane Serial Numbers 100-0001 thru 100-0149 or any aircraft equipped with P/N 302-129-402 main landing gear tire tubes. Active
(*** SB Number 15-04 Not Used ***)
SB15-03 RUDDER PULLEY BRACKET INSPECTION 06/09/2015 00 Mandatory KODIAK® 100 Series Airplane Serial Numbers 100‐0082 thru 100‐0107 Active
SB15-02 ALTERNATOR SENSE WIRE INSTALLATION 03/18/2015 00 Mandatory KODIAK® 100 Series Airplane Serial Numbers 100‐0001 thru 100‐0147 Active
SB15-01 YOKE ANTI-ROTATION GUIDE WEAR PAD UPGRADE 03/25/2015 00 Recommended KODIAK® 100 series airplane serial numbers 100-0001 thru 100-0149 Active
SB14-11 POROUS PANELS FLOW – CAV ICE PROTECTION SYSTEM 04/13/16 01 Recommended KODIAK® 100 airplanes certified prior to June 2013, or retrofitted with TKS ice protection system prior to June 2013. Active
SB14-10 RUDDER CABLE PASS-THROUGH DOUBLER INSTALLATION 10/31/2014 00 Mandatory KODIAK® 100 Series Aircraft Serial Numbers: 100-0001 through 100-0135 except with compliance to FSI-097, Aft Fuselage Skin Doubler Installation. Active
SB14-09 ELEVATOR DOUBLER INSTALLATION 12/11/2014 01 Mandatory Elevator Serial Numbers 0001 thru 0149 Active
SB14-08 WINGTIP NAVIGATION LIGHT REPLACEMENT 09/08/2014 00 Mandatory KODIAK® 100 Series Aircraft Serial Numbers: 100-0098 through 100-0114 Active
SB14-07 ELEVATOR CONTROL SYSTEM CUSHION EDGING INSPECTION 11/23/2015 01 Mandatory KODIAK® 100 Series Aircraft Serial Numbers: 100-0001 through 100-0149 Active
SB14-06 NOSE LANDING GEAR UPGRADES 06/19/2014 00 Recommended As required for KODIAK® 100 Series Aircraft Serial Numbers: 100-0001 thru 100-0124 Active
SB14-05 FLAP ACTUATOR DRIVE CABLE NUT TORQUE 06/12/2014 00 Mandatory KODIAK® 100 Series Aircraft Serial Numbers: 100-0001 thru 100-0085 Active
SB14-04 SLINGER RING INSPECTION 06/10/2014 00 Mandatory TKS™ Equipped KODIAK® 100 Series Aircraft Serial Numbers: 100-0001 through 100-0092 Active
SB14-03 TKS CONSOLE TANK LEVEL INDICATOR INSTALLATION 06/12/2014 01 Mandatory As required for TKS™ equipped KODIAK® 100 Series Aircraft Serial Numbers: 100-0001 thru 100-0114, with TKS™ installed prior to June 10, 2014 Active
SB14-02 AILERON LEADING EDGE SKIN AND NOSE RIB INSPECTION 01/27/2016 01 Mandatory KODIAK® 100 Series airplanes equipped with aileron P/N 100‐345‐0100 (Left) or P/N 100‐345‐0200 (Right) that have not performed FSI‐045 or FSI‐053. Active
SB14-01 EXTERNAL CARGO COMPARTMENT DRAIN HOLES 02/11/2014 00 Mandatory KODIAK® 100 Series Aircraft Serial Numbers: 100-0001 thru 100-0102 with External Cargo Compartments Active
SB13-10 INSPECTION AND REPLACEMENT OR MODIFICATION OF MASTER CONTROL UNIT 12/03/2013 00 Mandatory KODIAK® 100 Series Aircraft Serial Numbers: 100-0001 through 100-0096 Active
SB13-09 INSTALLATION OF HOBBS DISABLE PLACARDS 11/21/2013 00 Recommended KODIAK® 100 Series Aircraft Serial Numbers: 100-0072 through 100-0114 Active
SB13-08 VISOR BRACKET 11/18/2013 00 Mandatory KODIAK® 100 Series Aircraft Serial Numbers: 100-0001 through 100-0085 Active
SB13-07 SOFTWARE UPGRADE – OIL TEMPERATURE 10/08/2014 03 Mandatory KODIAK® 100 Series Aircraft Serial Numbers: 100-0001 thru 100-0103 Active
SB13-06 TEN THOUSAND HOUR LIFE EXTENSION FIELD RETROFIT 06/08/2013 00 Mandatory KODIAK® 100 Series Aircraft Serial Numbers: 100-0001 through 100-0094 Active
SB13-05 AFT FUSELAGE DRAIN HOLES 11/01/2013 00 Recommended KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0095 Active
SB13-04 MAIN LANDING GEAR FASTENER CORROSION PROTECTION 11/01/2013 00 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0074 Active
SB13-03 NOSE WHEEL SPACER INSTALLATION 11/01/2013 00 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0093 Active
SB13-02 ELEVATOR DOWN-STOP BUMPER REPLACEMENT 03/28/2013 01 Recommended As required for KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0090 Active
SB13-01 CARGO DOOR CATCH SWITCH ACTUATOR UPGRADE 01/16/2013 00 Recommended As required for KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0067 Active
SB12-08 WINDSHIELD SECURING SYSTEM INSTALLATION 05/16/2013 02 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-0001 thru 100-0076 Active
SB12-07 EXTERNAL CARGO COMPARTMENT JACK POINT REMOVAL 09/26/2012 00 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-0001 thru 100-0072 with External Cargo Compartments Active
SB12-06 WING SKIN FAY SURFACE SEAL APPLICATION INSTRUCTIONS 06/20/2012 00 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-0001 thru 100-0049 Active
SB12-05 NOSE LANDING GEAR SEAL AND CENTERING PIN REPLACEMENT 02/01/2018 01 Mandatory 100-0001 through100-0124, equipped with Centering Pin AN122719 Active
SB12-04 KODIAK 100 FUEL QUANTITY CALIBRATION 05/31/2012 00 Mandatory All KODIAK 100 Series Aircraft; see compliance section of Service Bulletin for details of applicability Rescinded
SB12-03 FLOOR BOARD SCREWS REPLACEMENT 05/10/2012 00 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0057 Active
SB12-02 COCKPIT FLOOR ACCESS PANEL INSTALLATION 04/24/2013 01 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-001 through 100-057 Active
SB12-01 AUTOPILOT SERVO CHAFE PROTECTION INSTALLATION 1/31/2012 00 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-001 through 100-061 Active
SB11-19 CREW DOOR ROLL PIN SAFETY WIRE INSTALLATION 11/11/2011 00 Recommended KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0059 Active
SB11-18 PITCH TRIM CABLE INSPECTION PROCEDURES 11/02/2011 00 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0055 Active
SB11-17 INERTIAL PARTICLE SEPERATOR BOLT REPLACEMENT 11/01/2011 00 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0056 Active
SB11-16 CREW SEAT STOP BRACKET ADDITION 10/07/2011 00 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0055 Active
SB11-15 CREW SEAT CHAIN PLATE INSPECTION 10/05/11 01 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0054 Active
SB11-14 WINDSHIELD BOND-LINE INSPECTION 09/22/2011 01 Mandatory KODIAK 100 Series Aircraft Serial Numbers 100-0001 through 100-0054 Active
SB11-13 HORIZONTAL ATTACH FITTING AFT SPAR INSPECTION 09/13/2011 01 Mandatory KODIAK 100 Series Aircraft Serial Numbers 100-0001 through 100-0047 Active
SB11-12 FUEL QUANTITY CALIBRATION PROCEDURES 08/05/2011 00 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0054 Active
SB11-11 BATTERY BOX REWORK 10/20/2011 00 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0057 Active
SB11-10 FUEL SELECTOR CABLE JAM NUT INSTALLATION 07/29/2011 00 Recommended KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0054 Active
SB11-09 BRAKE MASTER CYLINDER INSPECTION 08/01/2011 01 Recommended KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0052 Active
SB11-08 Spar Pass-Thru Hole and Tailcone Modification 6/24/11 00 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-001 through 100-045 Active
SB11-07 Nose Gear Piston Tube Cap Replacement 07/01/11 00 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-046 and 100-052 Active
SB11-06 MANDATORY RUDDER TRIM MOTOR INSPECTION 06/01/11 01 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-049 Active
SB11-05 MANDATORY ENGINE DRAIN LINE MODIFICATION 06/08/11 00 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0047, 100-0049, 100-0050, and 100-0052 Active
SB11-04 Garmin G1000 System Software Version 552.12 Upgrade 12/11/2012 01 Recommended KODIAK 100 Series Aircraft using Garmin G1000 System Software Versions 552.05, 552.08, 552.09, 552.10, or 552.11. Active
SB11-03 Engine Inlet Shroud Modification 3/16/2011 00 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0047 Active
SB11-02 RUDDER TRIM MOTOR SERVICING 2/9/2011 01 Mandatory FUEL SYSTEM; Mandatory Fuel Drain Valve Replacement Active
SB11-01 KODIAK 100 Nose Cowling Inspection, Fire Blanket Installation 1/31/11 00 Optional KODIAK 100 Series Aircraft Serial Numbers: 100-001 through 100-047 Active
SB-034 KODIAK 100 Fatigue Aft Fuselage Canted Frame Shear Clip Installation 12/9/10 00 This Service Bulletin may be complied with as convenient for the owner/operator but must be completed prior to exceeding the airframe hours listed in this Service Bulletin. Service Bulletin (SB-028 FATIGUE; AFT Fuselage Rivet Inspection) must be complied with prior to, or be completed in concurrence with this Service Bulletin. All KODIAK 100 Series Aircraft Active
SB-033 MANDATORY ONE-TIME MASTER BRAKE CYLINDER INSPECTION AND HEEL REST MODIFICATION 10/18/2010 A MANDATORY KODIAK 100 Series Aircraft,100-0001 thru 100-0044 Active
SB-032 MANDATORY ONE-TIME NOSE WHEEL STEERING BUNGEE INSPECTION & MODIFICATION 10/26/10 A MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0044 Active
SB-031 AFT FUSELAGE- Side Frame Fastener Inspection 9/17/2010 A MANDATORY KODIAK 100 Series Aircraft,100-0001 thru 100-0039 Active
SB-030 FLIGHT CONTROLS- Mandatory Balance Weight Inspection 7/22/2010 A MANDATORY KODIAK 100 Series Aircraft,100-0001 thru 100-0042 Active
SB-029 MANDATORY POH/AFM SUPPLEMENT ADDITION IN ACCORDANCE WITH KODIAK TCDS REVISION 10 3/3/2010 A MANDATORY KODIAK 100 Series Aircraft, 100-0035 Active
SB-028 AFT FUSELAGE RIVET INSPECTION AND DOUBLER INSTALLATION 06/07/2013 01 Mandatory KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0036 Active
SB-027 ELECTRICAL SYSTEM; Main and Essential Bus Fuse Inspection 1/26/2010 A MANDATORY KODIAK 100 Series Aircraft,100-0001 thru 100-0032 Active
SB-026 ELECTRICAL SYSTEM; Main Wiring Harness 11/25/2009 A MANDATORY KODIAK 100 Series Aircraft,100-0001 thru 100-0023 Active
SB-025 ELEVATOR TRIM CONTROL SYSTEM; Mandatory Visual Inspection 11/12/2009 A MANDATORY KODIAK 100 Series Aircraft,100-0013 thru 100-0015 and 100-0017 thru 100-0018 Active
SB-024 MANDATORY GARMIN G1000 SOFTWARE UPGRADE TO GDU VERSION 10.03 12/04/2012 03 MANDATORY All KODIAK 100 Series Aircraft currently using GARMIN 9.03 software. System Software Version 0552.04will be displayed in the upper right corner of the MFD splash screen. Active
SB-023 ELECTRICAL SYSTEM; Main Power Feed Cable 12/1/2009 A MANDATORY KODIAK 100 Series Aircraft,100-0001 thru 100-0029 Active
SB-022 PITOT STATIC SYSTEM; MANDATORY MODIFICATION 10/30/2009 B MANDATORY KODIAK 100 Series Aircraft,100-0001 thru 100-0022 Active
SB-021 MAIN LANDING GEAR; BRAKE LINE ADJUSTMENT 9/11/2009 A MANDATORY KODIAK 100 Series Aircraft,100-0001 thru 100-0022 Active
SB-020 FUSELAGE; MISSING FASTENERS 10/16/2009 A MANDATORY KODIAK 100 Series Aircraft,100-0001 thru 100-0014 Active
SB-019 CARGO DOOR; NOTICE REGARDING CARGO DOOR WINDOWS 7/8/2010 B MANDATORY All KODIAK 100 Series Aircraft Active
SB-018 FUEL SYSTEM; MANDATORY CHAFE PROTECTION ADDITION TO MAIN CABIN FUEL LINES 7/31/2009 A MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0019 Active
SB-017 FUEL SYSTEM; RESERVE FUEL BLADDER INSPECTION 7/21/2009 A MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0018 Active
SB-016 FLAP SYSTEM; FLAP DRIVE ACTUATOR REPLACEMENT 6/1/2010 B MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0018 Active
SB-015 MAIN LANDING GEAR; GREASE FITTINGS INSPECTION AND SPECIAL PRECAUTIONS. 4/23/2012 01 MANDATORY KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0061 Active
SB-014 FUEL SYSTEM; DOUBLER RING SCREW INSPECTION 7/17/09 A MANDATORY KODIAK 100 Series Aircraft, 100-0011 thru 100-0017 Active
SB-013 ELECTRICAL SYSTEM; GENERATOR CIRCUIT BREAKER CHECK PROCEDURE 6/12/2009 A MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0012 Active
SB-012 FUEL SYSTEM; MANDATORY INSPECTION (WING) 7/9/2009 B MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0009 Active
SB-011 FLIGHT SURFACES; ADJUSTMENT 6/7/2009 A MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0003 Active
SB-010 FUSELAGE; VERTICAL TAIL BOLT INSPECTION 6/9/2009 B MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0009 Active
SB-009 GARMIN AHRS VIBRATION TEST 4/20/2009 A MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0009 Active
SB-008 FUEL SYSTEM; Mandatory Fuel Drain Valve Resistance Test 4/14/2009 A MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0005 Active
SB-007 AMSAFE MANDATORY INERTIA REEL TEST 4/7/2009 A MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0012 Active
SB-006 LANDING GEAR; MAIN GEAR CROSS TUBES INSPECTION 4/7/2009 A MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0009 Active
SB-005 FUSELAGE; Mandatory Inspection 2/17/2009 A MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0009 Active
SB-004 ELECTRICAL; Potentiometer Replacement 1/26/2009 A MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0009 Active
SB-003 FUEL SYSTEM; Low Fuel Sensor Replacement 12/15/2008 A MANDATORY KODIAK 100 Series Aircraft, 100-0001 thru 100-0007 Active
SB-002 FUEL SYSTEM; Mandatory Fuel Drain Valve Replacement 4/23/2012 01 MANDATORY KODIAK 100 Series Aircraft Serial Numbers: 100-0001 through 100-0005 Active
SB-001 FLAP SYSTEM, Flap Actuation; Mandatory Inspection Procedures 6/1/2010 B MANDATORY SN 100-0018, unless SB-016 compliance has been met. ACTIVE